The IGBT module fails.

Elekton ESP VFDs (Elekton-05 and related): firmware versions, motor setup, trips, Modbus, and everyday operation.
AZor
User avatar
Posts: 11
Joined: Sun Jun 14, 2020 4:18 am

The IGBT module fails.

Post by AZor »

VSD Elekton 05. The IGBT module fails, one of two on one of the phases. replaced IGBT with a new one, started it at idle. During overclocking, IGBT failed again. They put in its place the neighboring one (from the same phase), and there was another new one there. Covered himself again in the same position. Question: Can the IGBT module fail due to a faulty driver board? Or maybe the cause of the malfunction lies in the DC circuit?
Original topic
СУ Электон 05. Выходит из строя модуль IGBT, один из двух на одной из фаз. заменили IGBT на новый, запустили на холостом ходу. Во время разгона IGBT опять вышел из строя. Поставили на его место соседний (с той же фазы), а туда ещё один новый. Накрылся опять на той же позиции. Вопрос: может ли выйти из строя IGBT модуль из-за неисправности платы драйвера? Или может в цепи постоянного тока кроется причина неисправности?
omega134134
User avatar
Posts: 9
Joined: Thu Dec 06, 2018 8:37 am

The IGBT module fails.

Post by omega134134 »

There are several options, if the VSD is old-style on single CM or FZ type transistors, then be sure to change the pair in phase, plus check the 2-6 Ohm resistors at the output of the drivers, if the VSD is new with a filter on semixes, then in detail each transistor with a limiter board on it, plus one common adapter board, and the skyper driver. And check the condition of the output choke, breakdown on the housing, and accordingly the sine capacitors
Original reply
вариантов несколько, если су старого образца на одиночных транзюках типа CM или FZ то меняй обязательно пару на фазе, плюс проверь резисторы по 2-6Ом на выходе драйверов, если су новая с фильтром на semix-ах то детально каждый транзистор с платой ограничителей на нем, плюс одна общая переходная плата, ну и драйвер skyper. И проверь состояние выходного дросселя пробой на корпус, соответсвенно и кондесаторы синуса
AZor
User avatar
Posts: 11
Joined: Sun Jun 14, 2020 4:18 am

The IGBT module fails.

Post by AZor »

Is it possible to test capacitors without desoldering them?
Original reply
Можно ли проверить конденсаторы не выпаивая их?
TMSnick70
User avatar
Posts: 11
Joined: Wed Jan 02, 2019 11:41 am

The IGBT module fails.

Post by TMSnick70 »

What does it mean to fail? What's breaking through? Gate - emitter, collector - emitter? What exactly? If the gate breaks, then most likely this is a malfunction of the pulse limiting circuits on the gate. If the collector - emitter breaks through, then this is either an overload in the load, or a driver malfunction - this is when the driver produces a curved (flat) front to the gate. And the answer is, can the module fail due to the driver? Certainly! I’m not an expert on stations, but our station technicians in such cases change drivers without hesitation. They use them in packs. Moreover, the removed drivers are immediately thrown into the trash, never to be seen again. And this does not mean that the cause of the malfunction can only be in the drivers...
Original reply
Что значит выходит из строя? Что пробивается? Затвор - эмитттер, коллектор - эмиттер? Что именно? Если пробивается затвор, то скорее всего это неисправность цепей ограничения импульса на затворе. Если пробивается коллектор - эмиттер, то это либо перегруз в нагрузке, либо неисправность драйвера — это когда драйвер выдаёт кривой(пологий) фронт на затвор. И ответ, может ли выйти из строя модуль из-за драйвера? Конечно! Я не спец по станциям, но у нас станционщики в подобных случаях меняют драйвера не задумываясь. Они у них расходуются упаковками. При чём снятые драйвера выкидывают на помойку сразу, чтобы больше никогда их не увидеть. И это не значит что причина неисправности может быть только в драйверах...