ESP intake module (MV / MVI)

Discuss gas separators, charge pumps, and gas handling devices. Technical forum on multiphase flow, gas interference, and advanced separation techniques
ALEngineer
Site Admin
User avatar
Posts: 530
Joined: Wed Mar 18, 2026 2:51 pm

ESP intake module (MV / MVI)

Post by ALEngineer »

The intake module (pump intake) takes in well fluid, does a coarse clean-up, connects the pump sections to the ESP motor / protector, and transmits torque from the motor shaft to the pump-section shafts.

MVI
Fig. 8.a __________________________________________________ Fig. 8.b

The intake module (Fig. 8.a, 8.b) consists of a base (1) with ports for formation fluid. Shaft (2) turns in sleeve bearings inside that base. The outside of the base is wrapped with intake screen (3). Spline coupling (4) connects the module shaft to the protector shaft of the motor.

The upper end of the module is made up to the middle pump section or to the gas separator with shipping studs (5, Fig. 8.a) or shipping screws (6, Fig. 8.b). The lower flange makes up to the protector with studs and nuts. For shipping and storage the intake module is closed with covers (7) and (8).

Wear-resistant intake module MVI, unlike the standard MV intake, has a sleeve bearing made of carbide bushing (9) and carbide wear sleeve (10).

A universal intake module (Fig. 8.b) was developed for these pump builds: with shaft thrust bearing 2..15 (2...19) ETsNAKI; without shaft thrust bearing 0...15 (0...19) ETsNAKI; compression pump 0615 (0619) ETsNAKI.

A special bolt (11) is screwed into the upper shaft end of the universal intake module. That bolt sets how far the shaft sits into the module base.

If you use the intake module with compression-pump sections 0615 (0619) ETsNAKI, back out that special bolt from the upper shaft end, screw in the adjusting bolt with radial lugs (stops) supplied in the install kit, and make a no-gap joint with the mounting adjustment device (UMR).

Drawing callouts (original scan kept as attachment below):
1. Base
2. Shaft
3. Intake screen
4. Spline coupling
5. Shipping stud
6. Shipping screw
7, 8. Shipping covers
9. Bearing bushing
10. Wear sleeve
11. Special bolt
12. Adjusting washer / shim
intake-module-MV-MVI.jpg
Original topic
Модуль входной служит для приема и грубой очистки перекачиваемой жидкости, для соединения секций с двигателем и передачи крутящего момента от вала двигателя к валам секций насоса.

МВИ
Рис 8.а __________________________________________________ Рис 8.б
Модуль входной (рис.8а, 8б) состоит из основания 1, с отверстиями для прохода пластовой жидкости, в котором в подшипниках скольжения вращается вал 2. Снаружи основание обтянуто приемной сеткой 3. Для соединения вала модуля с валом гидрозащиты двигателя служит шлицевая муфта 4. При помощи шпилек ресурсных 5 (рис.8а) или винтов ресурсных 6 (рис.8б) модуль верхним концом крепится к средней секции насоса или газосепаратору. Нижним фланцем входной модуль крепится к гидрозащите с помощью шпилек и гаек. На период транспортирования и хранения входной модуль закрыт крышками 7 и 8. Модуль входной износостойкий МВИ в отличие от модуля входного обычного исполнения МВ имеет подшипник скольжения, состоящий из твердосплавной втулки 9 и твердосплавной втулки защитной 10.
Для насосов конструктивных исполнений: с осевой опорой вала 2..15(2…19) ЭЦНАКИ, без осевой опоры вала 0…15(0…19)ЭЦНАКИ, компрессионного насоса 0615(0619) ЭЦНАКИ разработан универсальный модуль входной (рис.8б).

На верхнем торце вала универсального модуля входного ввернут болт специальный 11, с помощью которого выставляется требуемое заглубление вала в основании модуля.
В случае применения модуля входного с секциями компрессионного насоса 0615(0619)ЭЦНАКИ, необходимо вывернуть с верхнего торца вала модуля входного болт специальный, ввернуть болт регулировочный с радиальными выступами (фиксаторами), поставляемый с комплектом монтажных частей и обеспечить без-зазорное соединение с помощью устройства монтажного регулировочного (УМР).

7, 8. упаковочная крышка
9. втулка подшипника
10. втулка защитная
11. болт специальный
12. шайба регулировочная
intake-module-MV-MVI.jpg
You do not have the required permissions to view the files attached to this post.
apar1313@mail.ru
User avatar
Posts: 2
Joined: Sun Jul 21, 2019 11:36 pm

Re: ESP intake module (MV / MVI)

Post by apar1313@mail.ru »

Good afternoon!

I am looking for a procedure to press out and press in the press-fit carbide bushing of an ESP intake module. If you have a process or a method, please share.
Original reply
Добрый день!
Ищу методику выпрессовки и запрессовки втулки запрессовочной, твердосплавной входного модуля УЭЦН. Возможно у Вас есть технология, или методика?
ALEngineer
Site Admin
User avatar
Posts: 530
Joined: Wed Mar 18, 2026 2:51 pm

Re: ESP intake module (MV / MVI)

Post by ALEngineer »

I may be wrong, but the carbide one is the wear sleeve - it is not press-fit. The bearing bushing is the one that is pressed in.

The most I found on my side is the Novomet technical specification for intake modules: TU 3665-016-12058737-2015 Intake module and discharge module for submersible pumps. It is thin on this exact question.
Novomet intake and discharge module spec.zip
Original reply
Я могу ошибаться, но твердосплавная, это втулка защитная, она не запрессовывается. Запрессовывается втулка подшипника.
Максимум, что у себя нашел, это Новометовские технические условия на входные модули. ТУ 3665-016-12058737-2015 Модуль входной, модуль выкидной к погружным насосам. Но как бы по теме вопроса там жидковато.
Novomet intake and discharge module spec.zip
You do not have the required permissions to view the files attached to this post.
apar1313@mail.ru
User avatar
Posts: 2
Joined: Sun Jul 21, 2019 11:36 pm

Re: ESP intake module (MV / MVI)

Post by apar1313@mail.ru »

Thanks for the info. You are right - I meant the bearing bushing.
Original reply
спасибо за информацию, все верно ошибся, про втулку подшипника имел в виду.